email

 

A Manta permanent magnet alternator DC Drive motor or use on wind turbines to make power

Vertical Stator Design (Magnets on BOTH sides of the stator)

Worlds most powerful motor for its weight to hp ratio!

Over one hp per lb. / 28 horse power maximum - See details below

The next revolution in direct drive wind turbine technology!

LOTS OF LOW END POWER GENERATION ABILITY!

Fits on most common Etek bolt patterns and mounts

 

Permanent Magnet Motor /Generator

NO EXPENSIVE CONTROLLER REQUIRED

Let your battery voltage

be your speed controller.

  • · Low speed 6 volts
  • · Medium speed 12 volts.
  • · High speed 24 volts
  • · Hyper speed 48 volts
  • Just Plug & Play -

    • No expensive motor controller needed -

    Brush technology is older but they are very

    quick and simple to replace in the field AND

    brushed motors convert more electricity into

    usable horsepower! - 94% Electric Efficiency!

    Specifications:

    • · 7.91" diameter / 5.64" length
    • · 7/8" shaft with 3/16" keyway by 2.75" long (tapped center)
    • · Torque constant: 1.14 in-lb/Amp (0.13 Nm/Amp)
    • · 12V to 48V (has been run up to 96V / 45 sec. max. / 25 hp)
    • · 72 RPM per volt (3456rpm @ 48V / continuous duty)
    • · Can be used as a generator, makes power when turned (Requires 100 amp blocking diode)
    • · Great for VERY low voltages at high amp loads (Perfect PMG for making hydrogen)
    • · Perfect for building simple, cheap and dependable low voltage wind turbines.
    • · A put-up and forget design! Expect decades of dependable service life.
    • · Rain, ice and weather proof electronics.
    • · Lithium/Graphite brushes last up to 275,000 hours (When used as electric generator in wind power systems)
    • · 10 horsepower continuous duty at 48 volts.
    • · Max motor currents: 330A for 2 minutes / 480A for 45 seconds.
    • · 10 horsepower max at 48 volts continuous duty!
    • · 14 horsepower max at 60 volts continuous duty with optional air cooling port.
    • · 19 horsepower max at 72 volts for 2 minutes only!
    • · 28 horsepower max at 96 volts for 45 seconds only!
    • · Works for both CW or CCW rotations.
    • · Epoxy/Lam rotor efficiency = 94% (Brushed motors convert more electricity into usable horsepower)
    • · Weighs 10kg. / Dimensions - 8"X 9"X 9"
    • WARNING: this motor is NOT an ordinary motor, and should be handled with GREAT care.

      • It is very capable of serious power and should always be completely secured before applying any power to it.

       

    More idea’s here click on link

    http://www.hydrogenappliances.com/manta_ideas.html

    "A Real Power House for electric power generation from wind!"

    To give you engineering types some idea of how unusually hyper the #PMG226 is, try this test;

    Short out the power leads of the #PMG226 through an amp meter in line and try to turn the shaft by hand. While under a full load the shaft seems almost seized BUT during your fatiguing attempt to turn the shaft you will have produced well over a 35 amp reading on the amp meter!!!

    You say 35 amps just by turning the shaft by hand? YES! (This test may require vise-grip pliers for persons with weak grips)

    That's 35 amps at well under 1 RPS - WOW! Not bad for a direct drive unit!

    At last, a permanent magnet generator that does not require a gear box!

    Produce power at direct coupled wind turbine shaft speeds as low as 60 RPM!

    Designed to be directly mounted on 8 to 12 foot in diameter high speed wind turbine propellers

     

    [Home] [Hornets] [blades] [Blade Theory] [warning] [Fitting] [projects] [Turbine Kit] [Battery-tales] [Hub-Bub] [440amp relay] [Dump Load] [Dual relay] [Manta-PMA]